Gilsonite is a natural, brittle, and glisten tar hydrocarbon, which widely uses in the chemical, paint, and oil industry, besides asphalt production and thermal insulation. Major gangues of Gilsonite are gypsum, pyrite, silica, dolomite, calcite, and shale which are known as ash. Due to the fine liberation degree of gangue minerals from Gilsonite, most of the physical mineral processing methods are not applicable. Gilsonite has partially a behavior like coal in flotation due to its high carbon content and the similar composition of ash. As a result, flotation is one of the best methods to decrease the ash content of Gilsonite. In this study, four factors i.e. the dosage of collector, frother, and depressant, and solid to liquid ratio in three levels were examined in flotation to reduce the ash content and increase the recovery of Gilsonite. These tests were designed with the Taguchi method by Design-Expert software. Our results showed the lowest ash content of 5.2% was obtained in the condition which 200 g/t Gasoil as collector, 100 g/t MIBC as a frother, 300 g/t sodium silicate as a depressant, and pulp density was 5% solid to liquid weight ratio.
References
[1]
Shirazi, A. and Shirazy, A. (2020) Introducing Geotourism Attractions in Toroud Village, Semnan Province, Iran. International Journal of Science and Engineering Applications, 9, 79-86.
[2]
Shirazi, A., Shirazy, A. and Karami, J. (2018) Remote Sensing to Identify Copper Alterations and Promising Regions, Sarbishe, South Khorasan, Iran. International Journal of Geology and Earth Sciences, 4, 36-52.
[3]
Shirazi, A., et al. (2018) Remote Sensing Studies for Mapping of Iron Oxide Regions, South of Kerman, Iran. International Journal of Science and Engineering Applications, 7, 45-51. https://doi.org/10.7753/IJSEA0704.1002
[4]
Alahgholi, S., Shirazy, A. and Shirazi, A. (2018) Geostatistical Studies and Anomalous Elements Detection, Bardaskan Area, Iran. Open Journal of Geology, 8, 697-710. https://doi.org/10.4236/ojg.2018.87041
[5]
Shirazi, A., et al. (2018) Geostatistics Studies and Geochemical Modeling Based on Core Data, Sheytoor Iron Deposit, Iran. Journal of Geological Resource and Engineering, 6, 124-133. https://doi.org/10.17265/2328-2193/2018.03.004
[6]
Shirazi, A., et al. (2018) Exploration Geochemistry Data-Application for Cu Anomaly Separation Based on Classical and Modern Statistical Methods in South Khorasan, Iran. International Journal of Science and Engineering Applications, 7, 39-44. https://doi.org/10.7753/IJSEA0704.1001
[7]
Shirazy, A., Ziaii, M. and Hezarkhani, A. (2020) Geochemical Behavior Investigation Based on K-Means and Artificial Neural Network Prediction for Copper, in Kivi Region, Ardabil Province, Iran. Iranian Journal of Mining Engineering, 14, 96-112.
[8]
Shirazi, A. and Hezarkhani, A. (2018) Predicting Gold Grade in Tarq 1:100000 Geochemical Map Using the Behavior of Gold, Arsenic and Antimony by K-Means Method. Journal of Mineral Resources Engineering, 2, 11-23.
[9]
Shirazi, A., et al. (2018) Introducing a Software for Innovative Neuro-Fuzzy Clustering Method Named NFCMR. Global Journal of Computer Sciences: Theory and Research, 8, 62-69. https://doi.org/10.18844/gjcs.v8i2.3264
[10]
Shirazy, A., et al. (2019) Geochemical and Geostatistical Studies for Estimating Gold Grade in Tarq Prospect Area by K-Means Clustering Method. Open Journal of Geology, 9, 306-326. https://doi.org/10.4236/ojg.2019.96021
[11]
Shirazy, A., et al. (2020) Geostatistical and Remote Sensing Studies to Identify High Metallogenic Potential Regions in the Kivi Area of Iran. Minerals, 10, 869. https://doi.org/10.3390/min10100869
[12]
Boden, T. and Tripp, B.T. (2012) Gilsonite Veins of the Uinta Basin, Utah. Vol. 141. Utah Geological Survey.
[13]
Monson, B. and Parnell, J. (1992) The Origin of Gilsonite Vein Deposits in the Uinta Basin, Utah.
[14]
Carbognani, L., Espidel, J. and Izquierdo, A. (2000) Characterization of Asphaltenic Deposits from Oil Production and Transportation Operations. In: Developments in Petroleum Science, Elsevier, Amsterdam, 335-362. https://doi.org/10.1016/S0376-7361(09)70284-5
[15]
Nciri, N., et al. (2014) Chemical Characterization of Gilsonite Bitumen. Journal of Petroleum & Environmental Biotechnology, 5, 1.
[16]
Helms, J.R., et al. (2012) Structural Characterization of Gilsonite Bitumen by Advanced Nuclear Magnetic Resonance Spectroscopy and Ultrahigh Resolution Mass Spectrometry Revealing Pyrrolic and Aromatic Rings Substituted with Aliphatic Chains. Organic Geochemistry, 44, 21-36. https://doi.org/10.1016/j.orggeochem.2011.12.001
[17]
Jahanian, H., Shafabakhsh, G. and Divandari, H. (2017) Performance Evaluation of Hot Mix Asphalt (HMA) Containing Bitumen Modified with Gilsonite. Construction and Building Materials, 131, 156-164. https://doi.org/10.1016/j.conbuildmat.2016.11.069
[18]
Kok, B.V., Yilmaz, M. and Guler, M. (2011) Evaluation of High Temperature Performance of SBS+ Gilsonite Modified Binder. Fuel, 90, 3093-3099. https://doi.org/10.1016/j.fuel.2011.05.021
Co., A.G. (2020) Gilsonite History and Applications. http://www.americangilsonite.com
[21]
Ameri, M., et al. (2011) Technical Study on the Iranian Gilsonite as an Additive for Modification of Asphalt Binders Used in Pavement Construction. Construction and Building Materials, 25, 1379-1387. https://doi.org/10.1016/j.conbuildmat.2010.09.005
[22]
Glover, I.T. (1980) An Introduction to Coal Technology (Berkowitz, N.). Journal of Chemical Education, 57, A244. https://doi.org/10.1021/ed057pA244.1
[23]
Kogel, J.E., et al. (2006) Industrial Minerals & Rocks: Commodities, Markets, and Uses. SME, New York.
[24]
Almasi N. (2005) Bitumen Index in Ilam Province and Applied Activities on Them. 24th Geoscience Conference, Tehran, September 2005, 15-28.
[25]
Vélez, J.S., Velásquez, S. and Giraldo, D. (2016) Mechanical and Rheometric Properties of Gilsonite/Carbon Black/Natural Rubber Compounds Cured Using Conventional and Efficient Vulcanization Systems. Polymer Testing, 56, 1-9. https://doi.org/10.1016/j.polymertesting.2016.09.005
[26]
Burton, D.K. (1996) A History of Uintah County: Scratching the Surface. Utah State Historical Society.
[27]
Khodarahmi, A., Habibi, M. and Bahrami, A. (2006) Gilsonite Processing by Gravity Method. 25th Geoscience Conference, Tehran, November 2006, 59-67.
[28]
Krahulec, K. (2008) 2008 Summary of Mineral Activity in Utah.
[29]
Aflaki, S. and Tabatabaee, N. (2009) Proposals for Modification of Iranian Bitumen to Meet the Climatic Requirements of Iran. Construction and Building Materials, 23, 2141-2150. https://doi.org/10.1016/j.conbuildmat.2008.12.014
[30]
Khakmardan, S., et al. (2018) Copper Oxide Ore Leaching Ability and Cementation Behavior, Mesgaran Deposit in IRAN. Open Journal of Geology, 8, 841. https://doi.org/10.4236/ojg.2018.89049
[31]
Wills, B.A. and Finch, J. (2015) Wills’ Mineral Processing Technology: An Introduction to the Practical Aspects of Ore Treatment and Mineral Recovery. Butterworth-Heinemann, Oxford. https://doi.org/10.1016/B978-0-08-097053-0.00001-7
[32]
Fornasiero, D. and Filippov, L. (2017) Innovations in the Flotation of Fine and Coarse Particles. Journal of Physics: Conference Series, 879, Article ID: 012002. https://doi.org/10.1088/1742-6596/879/1/012002
[33]
Farrokhpay, S., Filippov, L. and Fornasiero, D. (2020) Flotation of Fine Particles: A Review. Mineral Processing and Extractive Metallurgy Review. https://doi.org/10.1080/08827508.2020.1793140
ASTM, ASTM D3174-12 (2012) Standard Test Method for Ash in the Analysis Sample of Coal and Coke from Coal. ASTM International, West Conshohocken.
[36]
Rezaei, B. (1996) Flotation. 2nd Edition, Hormozgan University Publication, Bandar Abbas.
[37]
Rezaei, B. (2001) Coal Cleaning Technology. Amirkabir University of Technology Publication, Tehran.
[38]
Rezai, B. (1998) Mineral Processing Technology (Beneficiation with Gravity Methods). Hormozgan University Publication, Bandar Abbas.
[39]
Wei, T., Peng, Y. and Farrokhpay, S. (2014) Froth Stability of Coal Flotation in Saline Water. Mineral Processing and Extractive Metallurgy, 123, 234-240. https://doi.org/10.1179/1743285514Y.0000000077
[40]
Lide, D.R. (1993) Handbook of Chemistry and Physics. CRC Press, Boca Raton, 1.
