|
|
- 2016
考虑不完全维修的海底管道视情维修优化策略
|
Abstract:
在海底管道维修中, 设备的恢复状况有限, 不合理的维修策略往往会导致维修过剩或者维修不足, 影响经济效益．为此, 建立了单部件系统在不完全维修条件下的最佳维修费用率的数学模型, 得到了设备劣化状态分布的概率密度函数．根据连续的Gamma分布, 对海底管道的劣化过程进行了应用研究, 将预防性维修和故障性更换相结合, 给出了模型的数值算例, 通过对无限使用期下费用率的灵敏度分析, 验证了方法的适用性和可靠性．
In the submarine pipeline repair process，limited equipment recovery and unreasonable maintenance policy often lead to bad maintenance and poor economic profits. For single-unit system，a new mathematical model under imperfect repair was developed for the best maintenance expense ratio，and the probability density function of degradation state distribution was obtained. Application studies for the deterioration process were conducted based on continuous Gamma distribution，and by combining the preventative maintenance and replacement due to failure，the sensitivity of long-run cost was analyzed numerically. The simulation results prove the applicability and reliability of the optimization model
| [1] | Li Xiaosen, Chen Qi, Li Gang, et al. The simulation of hydrate production by depressurization in deep ocean [J]. <i>Geoscience</i>, 2010, 24(3):598-606(in Chinese). |
| [2] | 余建星, 周宝勇, 周清基, 等. 海底管道SSIV设置研究[J]. 天津大学学报, 2011, 44(7):565-570. |
| [3] | Yu Jianxing, Zhou Baoyong, Zhou Qingji, et al. Research of installing SSIV on subsea pipeline[J]. <i>Journal of Tianjin University</i>, 2011, 44(7):565-570(in Chinese). |
| [4] | 金伟良, 张恩勇, 邵剑文, 等. 海底管道失效原因分析及其对策[J]. 科技通报, 2004, 20(6):529-533. |
| [5] | Yi Dongbo, Bao Yukun. Stochastic dynamic lot sizing decision with Erlang distribution[J]. <i>Journal of Wuhan University of Technology</i>:<i>Information & Management Engineering</i>, 2012, 34 (1):87-92(in Chinese). |
| [6] | Huang Jianxin, Bian Yaqin. Materiel on-condition maintenance decision analysis on condition-based reliability [J]. <i>Fire Control and Command Control</i>, 2011, 36(10):134-137(in Chinese). |
| [7] | Xu Wenjing. Research on Availability and Maintenance Policy Under Imperfect Repair[D]. Changsha:School of Management Science and Engineering, National University of Defense Technology, 2008(in Chinese). |
| [8] | Gu Yubo, Jia Yunxian, Zhang Yingbo. Study on residual life prediction and maintenance decision-making optimal model based on Gamma deterioration process[J]. <i>Bearing</i>, 2013(4):44-49(in Chinese). |
| [9] | 谷玉波, 贾云献, 张英波. 基于Gamma退化过程的剩余寿命预测及维修决策优化模型研究[J]. 轴承, 2013(4):44-49. |
| [10] | 张占奎. 油气管道腐蚀失效预测及安全可靠性评估研究[D]. 天津:天津大学建筑工程学院, 2006. |
| [11] | Zhang Zhankui. Study on Corrosion Failure Prediction and Reliability Evaluation of Oil Transmission Pipeline [D]. Tianjin:School of Civil Engineering, Tianjin University, 2006(in Chinese). |
| [12] | Jin Weiliang, Zhang Enyong, Shao Jianwen, et al. Cause analysis and countermeasure for submarine pipeline failure[J]. <i>Bulletin of Science and Technology</i>, 2004, 20(6):529-533(in Chinese). |
| [13] | 刘楚, 王佐强, 韩长安. 海底管道事故类型及维修方法综述[J]. 中国石油和化工标准与质量, 2012, 33(15):254-255. |
| [14] | Liu Chu, Wang Zuoqiang, Han Chang’an. Review on types and maintenance methods of submarine pipeline accidents[J]. <i>China Petroleum and Chemical Standard and Quality</i>, 2012, 33(15):254-255(in Chinese). |
| [15] | 刘春厚, 潘东民, 吴谊山. 海底管道维修方法综述[J]. 中国海上油气, 2004, 16(1):61-64. |
| [16] | 狄鹏, 黎放, 杨元. 基于机会维修策略的预防性维修优化模型研究[J]. 工程设计学报, 2012, 19(4):263-267, 273. |
| [17] | Antoine G, Laurence D, Christophe B, et al. Continuous-time predictive-maintenance scheduling for a deteriorating system[J]. <i>IEEE Transactions on Reliability</i>, 2002, 51(2):141-150. |
| [18] | Xu Li, Li Qingmin, Ruan Minzhi. Support project optimization for warship formation with finite repair capacity[J]. <i>Systems Engineering and Electrics</i>, 2014, 36(11):2226-2232(in Chinese). |
| [19] | Zhang Xin, Yu Jianxing, Liang Jing, et al. Application of risk based inspection(RBI)in the quantitative risk assessment of subsea pipeline[J]. <i>Oil Field Equipment</i>, 2015, 44(1):9-12(in Chinese). |
| [20] | 王凌. 维修决策模型和方法的理论与应用研究[D]. 杭州:浙江大学信息科学与工程学院, 2007. |
| [21] | Wang Ling. Models and Methods for Maintenance Decisions:Theory and Applications[D]. Hangzhou:School of Information Science and Engineering, Zhejiang University, 2007(in Chinese). |
| [22] | 易东波, 鲍玉昆. 基于爱尔朗分布的随机动态批量决策研究[J]. 武汉理工大学学报:信息与管理工程版, 2012, 34(1):87-92. |
| [23] | 黄建新, 边亚琴. 状态可靠性的装备视情维修决策分析[J]. 火力与指挥控制, 2011, 36(10):134-137. |
| [24] | 徐文静. 不完全维修条件下的可用度与维修策略分析[D]. 长沙:国防科学技术大学管理科学与工程学院, 2008. |
| [25] | 李小森, 陈琦, 李刚, 等. 海底水合物矿藏降压开采与甲烷气体扩散过程的数值模拟[J]. 现代地质, 2010, 24(3):598-606. |
| [26] | Zhang Liang, Wu Han, Yu Yang, et al. Axial and transverse coupled vibration characteristics of deep-water riser with internal flow[J]. <i>Procedia Engineering</i>, 2015, 126:260-264. |
| [27] | Liu Chunhou, Pan Dongmin, Wu Yishan. Review of submarine pipeline maintenance methods [J]. <i>China Offshore Oil and Gas</i>, 2004, 16(1):61-64(in Chinese). |
| [28] | Di Peng, Li Fang, Yang Yuan. Optimal preventive maintenance model based on opportunistic maintenance policy[J]. <i>Chinese Journal of Engineering Design</i>, 2012, 19(4):263-267, 273(in Chinese). |
| [29] | 徐立, 李庆民, 阮？F智. 具备有限维修能力的舰船编队保障方案优化[J]. 系统工程与电子技术, 2014, 36(11):2226-2232. |
| [30] | 张欣, 余建星, 梁静, 等. 基于风险的检测(RBI)在海底管道定量风险评估中的应用[J]. 石油 矿场机械, 2015, 44(1):9-12. |
