|
|
- 2018
海藻酸钙@Fe3O4/生物碳磁性复合材料的制备及其对Co (II)的吸附性能和机制
|
Abstract:
利用海藻酸钙（CA）包覆生物碳（BC）、Fe3O4制备了一种新型磁性微球（CA@Fe3O4/BC），用以吸附水溶液中的Co（Ⅱ）。系统的研究了Co（NO3）2溶液浓度、pH和时间对吸附的影响。CA@Fe3O4/BC吸附Co（Ⅱ）等温热力学数据符合Langmuir模型，在pH=6的条件下对Co（Ⅱ）的最大吸附量为16.23 mg/g。研究显示，CA@Fe3O4/BC存在显著的协同效应，对Co（Ⅱ）具有更好的吸附性能。由于磁性颗粒的存在，CA@Fe3O4/BC吸附Co（Ⅱ）后可以用磁铁吸附快速分离。CA@Fe3O4/BC吸附Co（Ⅱ）动力学数据符合准二级动力学模型，研究表明，CA@Fe3O4/BC吸附Co（Ⅱ）的机制主要包括形成配合物及Ca（Ⅱ）与Co（Ⅱ）发生离子交换。 A magnetic microspheres (Calcium Alginate@Fe3O4/Biochar) was prepared using calcium alginate (CA) encapsulated biochar (BC) and Fe3O4 as the green adsorbent for Co(Ⅱ) removal from aqueous solution. The effects of the initial Co(NO3)2 concentration, initial pH value of Co(Ⅱ) solution and equilibrium contact time were investigated on CA@Fe3O4/BC. The isothermal thermodynamic datas of the CA@Fe3O4/BC conformed to the Langmuir model. The maximum adsorption capacity of the CA@Fe3O4/BC from the Langmuir equation is 16.23 mg·g-1 at pH=6. It appears a synergistic effect between biochar and Fe3O4 in CA, which enhances the maximum adsorption capacity of Co(Ⅱ) ion. The presence of the magnetic particles in magnetic microsphere allows easy isolation of the material from aqueous solutions by using a magnet. The adsorptions of Co(Ⅱ) by the CA@Fe3O4/BC are in good agreement with pseudo-second-order kinetic. The mechanism studies for Co (Ⅱ) removal by the CA@Fe3O4/BC show that the nature of Co(Ⅱ) abstraction takes place through the ion exchange between Ca(Ⅱ) and Co(Ⅱ) as well as the formation of coordination complex. 海南省重点研发计划项目（ZDYF2017102）；海南省自然科学基金（20162032）；海南省精细化工工程技术研究中心开放课题；海南师范大学2017年度"大学生创新创业训练计划"项目
| [1] | IDRIS A, ISMAIL N, HASSAN N, et al. Synthesis of magnetic alginate beads based on maghemite nanoparticles for Pb(ii) removal in aqueous solution[J]. Journal of Industrial and Engineering Chemistry, 2012, 18(5):1582-1589. |
| [2] | WU T, MAO L, WANG H. Adsorption of fluoride from aqueous solution by using hybrid adsorbent fabricated with Mg/Fe composite oxide and alginate via a facile method[J]. Journal of Fluorine Chemistry, 2017, 200:8-17. |
| [3] | YAN L, LI S, YU H, et al. Facile solvothermal synthesis of Fe3O4/bentonite for efficient removal of heavy metals from aqueous solution[J]. Powder Technology, 2016, 301:632-640. |
| [4] | CHEN Y, MU S. Core-shell structured Fe3O4 nanoparticles functionalized with rhodamine derived probe for the detection, adsorption and removal of Hg(ii):A sensing system with 'warning' signal[J]. Sensors and Actuators B:Chemical, 2014, 192(192):275-282. |
| [5] | TRAKAL L, VESELSKA V, SAFARIK I, et al. Lead and cadmium sorption mechanisms on magnetically modified biochars[J]. Bioresource Technology, 2016, 203:318-324. |
| [6] | HAN Z, SANI B, MROZIK W, et al. Magnetite impregnation effects on the sorbent properties of activated carbons and biochars[J]. Water Research, 2015, 70:394-403. |
| [7] | 谢水波, 罗景阳, 刘清, 等. 羟乙基纤维素/海藻酸钠复合膜对六价铀的吸附性能及吸附机制[J]. 复合材料学报, 2015, 32(1):268-275. XIE S B, LUO J Y, LIU Q, et al. Adsorption characteristics and mechanism of hydroxyethyl cellulose/sodium alginate blend film for uranium(Ⅵ)[J]. Acta Materiae Compositae Sinica, 2015, 32(1):268-275(in Chinese). |
| [8] | TAVAKOLI H, SEPEHRIAN H, CHERAGHALI R. Encapsulation of nanoporous mcm-41 in biopolymeric matrix of calcium alginate and its use as effective adsorbent for lead ions:Equilibrium, kinetic and thermodynamic studies[J]. Journal of the Taiwan Institute of Chemical Engineers, 2013, 44(3):343-348. |
| [9] | SIGDEL A, JUNG W, MIN B, et al. Concurrent removal of cadmium and benzene from aqueous solution by powdered activated carbon impregnated alginate beads[J]. Catena, 2017, 148:101-107. |
| [10] | ZHANG S XU F, WANG Y, et al. Silica modified calcium alginate-xanthan gum hybrid bead composites for the removal and recovery of Pb(Ⅱ) from aqueous solution[J]. Chemical Engineering Journal, 2013, 234(12):33-42. |
| [11] | TALEB M. Adsorption and photocatalytic degradation of 2-cp in wastewater onto CS/CoFe2O4 nanocomposite synthesized using gamma radiation[J]. Carbohydrate Polymers, 2014, 114:65-72. |
| [12] | JUNG K W, JEONG T U, KANG H J, et al. Characteristics of biochar derived from marine macroalgae and fabrication of granular biochar by entrapment in calcium-alginate beads for phosphate removal from aqueous solution[J]. Bioresource Technology, 2016, 211:108-116. |
| [13] | BHATNAGAR A, MINOCHA A K, SILLANP？？ M. Adsorptive removal of cobalt from aqueous solution by utilizing lemon peel as biosorbent[J]. Biochemical Engineering Journal, 2010, 48(2):181-186. |
| [14] | KHAN M, YILMAZ E, SOYLAK M. Vortex assisted magnetic solid phase extraction of lead(ii) and cobalt(ii) on silica coated magnetic multiwalled carbon nanotubes impregnated with 1-(2-pyridylazo-2-naphthol)[J]. Journal of Molecular Liquids, 2016, 224:639-647. |
| [15] | MARTIN C B, LECLERCQ S, BARBOUX P, et al. Sorption of nickel and cobalt ions onto cobalt and nickel ferrites[J]. Journal of Colloid and Interface Science, 2011. 360(2):695-700. |
| [16] | AWUAL M R, ISMAEL M, YAITA T. Efficient detection and extraction of cobalt(ii) from lithium ion batteries and wastewater by novel composite adsorbent[J]. Sensors and Actuators B:Chemical, 2014, 191:9-18. |
| [17] | LI M, LIU Q, GUO L, et al. Cu(Ⅱ) removal from aqueous solution by spartina alterniflora derived biochar[J]. Bioresource Technology, 2013, 141(4):83-88. |
| [18] | MOHAN D, SINGH P, SARSWAT A, et al. Lead sorptive removal using magnetic and nonmagnetic fast pyrolysis energy cane biochars[J]. Journal of Colloid and Interface Science, 2015, 448:238-250. |
| [19] | 刘东, 赵孔银, 宋欢语, 等. 硅酸钙-海藻酸钙复合水凝胶膜的制备及表征[J]. 复合材料学报, 2017, 34(11):2401-2406. LIU Dong, ZHAO Kongyin, SONG Huanyu, et al. Preparation and characterization of calcium silicate-calcium alginate composite hydrogel film[J]. Acta Materiae Compositae Sinica, 2017, 34(11):2401-2406(in Chinese). |
| [20] | LI Y, DU Q, LIU T, et al. Methylene blue adsorption on graphene oxide/calcium alginatecomposites[J]. Carbohydrate Polymers, 2013, 95(1):501-507. |
| [21] | 蔺洪全, 赵孔银, 马敬环, 等. TiO2-海藻酸钙复合膜的表征、对染料的光催化降解及TiO2回收[J]. 复合材料学报, 2015, 32(3):911-917. LIN H Q, ZHAO K Y, MA J H, et al. Characterization and dyes photocatalytic degradation of TiO2-calcium alginate composite films and recycle of TiO2[J]. Acta Materiae Compositae Sinica, 2015, 32(3):911-917(in Chinese). |
| [22] | YANG Y, WEI Z, ZHANG X, et al. Biochar from alternanthera philoxeroides could remove Pb(Ⅱ) efficiently[J]. Bioresource Technology, 2014, 171(1):227-232. |
| [23] | LI J, CHEN C, ZHAO Y, et al. Synthesis of water-dispersible Fe3O4@β-cyclodextrin by plasma-induced grafting technique for pollutant treatment[J]. Chemical Engineering Journal, 2013, 229:296-303. |
| [24] | YU C, GENG J, ZHUANG Y, et al. Preparation of the chitosan grafted poly (quaternary ammonium)/Fe3O4 nanoparticles and its adsorption performance for food yellow 3[J]. Carbohydrate Polymers, 2016, 152:327-336. |
| [25] | VERMA R, ASTHANA A, SINGH A K, et al. Novel glycine-functionalized magnetic nanoparticles entrapped calcium alginate beads for effective removal of lead[J]. Microchemical Journal, 2017, 130:168-178. |
| [26] | ZHOU B, WANG Z, SHEN D, et al. Low cost earthworm manure-derived carbon material for the adsorption of Cu2+ from aqueous solution:Impact of pyrolysis temperature[J]. Ecological Engineering, 2017, 98:189-195. |
| [27] | CUI X, DAI X, KHAN K Y, et al. Removal of phosphate from aqueous solution using magnesium-alginate/chitosan modified biochar microspheres derived from thalia dealbata[J]. Bioresource Technology, 2016, 218:1123-1132. |
| [28] | LI J, ZHANG S, CHEN C, et al. Removal of Cu(ii) and fulvic acid by graphene oxide nanosheets decorated with Fe3O4 nanoparticles[J]. ACS Applied Materials & Interfaces, 2012, 4(9):4991-5000. |
| [29] | GUO Y, TANG W, WU J, et al. Mechanism of Cu(Ⅱ) adsorption inhibition on biochar by its aging process[J]. Journal of Environmental Sciences, 2014, 26(10):2123-2130. |
| [30] | XU Y, ZHOU Y, LI R. Simultaneous fluorescence response and adsorption of functionalized Fe3O4@SiO2 nanoparticles to Cd2+, Zn2+ and Cu2+[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2014, 459(14):240-246. |
| [31] | YAN L G, YANG K, SHAN R R, et al. Kinetic, isotherm and thermodynamic investigations of phosphate adsorption onto core-shell Fe3O4@ldhs composites with easy magnetic separation assistance[J]. Journal of Colloid and Interface Science, 2015, 448:508-516. |
| [32] | ALGOTHMI W M, BANDARU N M, YU Y, et al. Alginate-graphene oxide hybrid gel beads:An efficient copper adsorbent material[J]. Journal of Colloid and Interface Science, 2013, 397(5):32-38. |
| [33] | ZHANG C J, LIU Y, CUI L, et al. Bio-based calcium alginate nonwoven fabrics:Flame retardant and thermal degradation properties[J]. Journal of Analytical and Applied Pyrolysis, 2016, 122:13-23. |
| [34] | MOUSA N E, SIMONESCU C M, PATESCU R E, et al. Pb2+ removal from aqueous synthetic solutions by calcium alginate and chitosan coated calcium alginate[J]. Reactive and Functional Polymers, 2016, 109:137-150. |
| [35] | PLATERO E, FERNANDEZ M E, BONELLI P R, et al. Graphene oxide/alginate beads as adsorbents:Influence of the load and the drying method on their physicochemical-mechanical properties andadsorptive performance[J]. Journal of Colloid and Interface Science, 2017, 491:1-12. |
| [36] | JIANG N, XU Y, DAI Y, et al. Polyaniline nanofibers assembled on alginate microsphere for Cu2+ and Pb2+ uptake[J]. Journal of Hazardous Materials, 2012, 215-216(4):17-24. |
| [37] | DO X H, LEE B K. Removal of Pb2+using a biochar-alginate capsule in aqueous solution and capsule regeneration[J]. Journal of Environmental Management, 2013, 131:375-382. |
| [38] | TAYYEBI A, OUTOKESH M, MORADI S, et al. Synthesis and characterization of ultrasound assisted "graphene oxide-magnetite" hybrid, and investigation of its adsorption properties for Sr(ii) and Co(ii) ions[J]. Applied Surface Science, 2015, 353(343):350-362. |
| [39] | BOIS L, BONHOMME A, RIBES A, et al. Functionalized silica for heavy metal ions adsorption[J]. Colloids and Surfaces A:Physicochemical and Engineering Aspects, 2003, 221(1-3):221-230. |
| [40] | VILVANATHAN S, SHANTHAKUMAR S. Biosorption of Co(ii) ions from aqueous solution using chrysanthemum indicum:Kinetics equilibrium and thermodynamics[J]. Process Safety and Environmental Protection, 2015, 96:98-110. |
| [41] | KUSHWAHA A K, GUPTA N, CHATTOPADHYAYA M C. Dynamics of adsorption of Ni(ii), Co(ii) and Cu(ii) from aqueous solution onto newly synthesized poly[n-(4-[4-(aminophenyl)methylphenylmethacrylamide])] [J]. Arabian Journal of Chemistry, 2017, 10:1645-1653. |
| [42] | GUPTA N, KUSHWAHA A K, CHATTOPADHYAYA M C. Adsorptive removal of Pb2+, Co2+and Ni2+ by hydroxyapatite/chitosan composite from aqueous solution[J]. Journal of the Taiwan Institute of Chemical Engineers, 2012, 43(1):125-131. |
| [43] | EEDEM E, KARAPINAR N, DONAT R. The removal of heavy metal cations by natural zeolites[J]. Journal of Colloid and Interface Science, 2004, 280(2):309-314. |
| [44] | BORDOLOI N, GOSWAMI R, KUMAR M, et al. Biosorption of Co(ii) from aqueous solution using algal biochar:Kinetics and isotherm studies[J]. Bioresource Technology, 2017, 244:1465-1469. |
| [45] | ROH H, YU M R, YAKKALA K, et al. Removal studies of Cd(ii) and explosive compounds using buffalo weed biochar-alginate beads[J]. Journal of Industrial and Engineering Chemistry, 2015, 26:226-233. |
| [46] | HASSAN A F, ABDEL MOHSEN A M, ELHADIDY H. Adsorption of arsenic by activated carbon, calcium alginate and their composite beads[J]. International Journal of Biological Macromolecules, 2014, 68(7):125-130. |
| [47] | BAGHERI A R, GHAEDI M, ASFARAM A, et al. Comparative study on ultrasonic assisted adsorption of dyes from single system onto Fe3O4 magnetite nanoparticles loaded on activated carbon:Experimental design methodology[J]. Ultrasonics Sonochemistry, 2017, 34:294-304. |
| [48] | REN H, GAO Z, WU D, et al. Efficient Pb(Ⅱ) removal using sodium alginate-carboxymethyl cellulose gel beads:Preparation, characterization, and adsorption mechanism[J]. Carbohydr Polym, 2016, 137:402-409. |
