|
|
- 2016
Ag-羧甲基壳聚糖复合微粒的制备及其抑菌活性
|
Abstract:
壳聚糖经羧甲基化改性后得到水溶性较高的羧甲基壳聚糖（OCMC），它具有优良的稳定性和抗菌性。对比OCMC在不同溶剂中的溶解度，发现OCMC在2wt%乙酸溶液中的溶解性最好。将OCMC与纳米Ag（AgNPs）复合得到Ag-OCMC复合微粒，采用UV-Vis、FTIR、XPS、TEM、SEM和TG-DTA对Ag-OCMC复合微粒的组成、微观结构和热性能进行表征。以大肠杆菌和金黄色葡萄球菌为模型菌种测试Ag-OCMC复合微粒对革兰氏菌的抗菌性能。结果表明：AgNPs为面心立方晶型，平均粒径为40~50 nm；AgNPs的引入提高了壳聚糖和OCMC的分解温度。Ag-OCMC复合微粒对革兰氏菌的抑菌活性明显高于单一壳聚糖基抗菌剂。 Carboxymethyl-chitosan (OCMC) with high water solubilities was obtained by carboxymethylation of chitosan. It has good stability and antibacterial property. Comparing the solubility of OCMC dissolving in difference solvents, it is found that the best solvent condition of OCMC is 2wt% acetic acid aqueous. The Ag-OCMC composite particles were obtained by complex of OCMC and Ag nanoparticles (AgNPs). The composition, microstructure and thermal properties of Ag-OCMC composite particles were characterized by UV-Vis, FTIR, XPS, TEM, SEM and TG-DTA. Antimicrobial activities of Ag-OCMC composite particles were performed by using typical bacteria of E.coli and S.aureus. The results show that AgNPs are face-centered cubic crystallites with the average diameter size in 40-50 nm. The decomposition temperatures of chitosan and OCMC are raised by the introduction of AgNPs. The antibacterial activity of Ag-OCMC composite particles is significantly higher than single chitosan based antibacterials. 国家自然科学基金（51203042）；河北省自然科学基金（E2012208046）
| [1] | LV J, ZHOU Q, LIU G, et al. Preparation and properties of polyester fabrics grafted with O-carboxymethyl chitosan[J]. Carbohydrate Polymers, 2014, 113: 344-352. |
| [2] | JIANG L, LU Y, LIU X, et al. Layer-by-layer immobilization of quaternized carboxymethyl chitosan/organic rectorite and alginate onto nanofibrous mats andtheir antibacterial application[J]. Carbohydrate Polymers, 2015, 121: 428-435. |
| [3] | 安静. 银/聚合物纳米材料的制备、结构和抗菌性能研究[D]. 天津: 天津大学, 2009. AN J. Preparation, structure, and antibacterial activities of silver/polymer nanocomposites[D]. Tianjin: Tianjin University, 2009 (in Chinese). |
| [4] | 张贵芹, 赵丽瑞, 刘满英. O-羧甲基壳聚糖的制备及波谱分析[J]. 光谱实验室, 2006, 23(4): 658-661. ZHANG G Q, ZHAO L R, LIU M Y. Preparation and spectroscopic analysis of O-carboxymethyl chitosan[J]. Chinese Journal of Spectroscopy Laboratory, 2006, 23(4): 658-661 (in Chinese). |
| [5] | AJITHA B, ASHOK K R Y, SREEDHARA R P. Biogenic nano-scale silver particles by Tephrosia purpurea leaf extract and their inborn antimicrobial activity[J]. Spectrochimica Acta Part A: Molecular and Biomolecular Spectroscopy, 2014, 121(5): 164-172. |
| [6] | KUMAR M S, KIRUBANANDAN S, SRIPRIYA R, et al. Triphala promotes healing of infected full-thickness dermal wound[J]. Surgical Research, 2008, 144(1): 94-101. |
| [7] | DUCHOSLAV J, ARNDT M, STEINBERGER R, et al. Nanoscopic view on the initial stages of corrosion of hot dip galvanized Zn-Mg-Al coatings[J]. Corrosio Science, 2014, 83: 327-334. |
| [8] | MURALI M Y, VIMALA K, THOMAS V, et al. Controlling of silver nanoparticles structure by hydrogel networks[J]. Colloid and Interface Science, 2010, 342(1): 73-82. |
| [9] | THOMAS V, YALLAPU M M, SREEDHAR B, et al. A versatile strategy to fabricate hydrogel-silver nanocomposites and investigation of their antimicrobial activity[J]. Colloid and Interface Science, 2007, 315(1): 389-395. |
| [10] | LONG Y, RAN X, ZHANG L. A method for the preparation of silver nanoparticles using commercially available carboxy methyl chitosan and sunlight[J]. Materials Letters, 2013, 112: 101-104. |
| [11] | 安静, 罗青枝, 李雪艳, 等. 银/壳聚糖-g-甲基丙烯酸甲酯复合物的制备与抗菌性能[J]. 复合材料学报, 2011, 28(3): 127-134. AN J, LUO Q Z, LI X Y, et al. Preparation and antibacterial properties of silver/chitosan-g-methyl methacrylate[J]. Acta Meteriae Compositae Sinica, 2011, 28(3): 127-134 (in Chinese). |
| [12] | MOSTAFA M, RAMADAN H E, EL-AMIR M A. Sorption and desorption studies of radioiodine onto silver chloride via batch equilibration with its aqueous media[J]. Journal of Environmental Radioactivity, 2015, 150: 9-19. |
| [13] | GREULICH C, DIENDORF J, GESSMANN J, et al. Cell type-specific responses of peripheral blood mononuclear cells to silver nanoparticles[J]. Acta Biomaterialia, 2011, 7(9): 3505-3514. |
| [14] | KIM S Y, SHIN S, KOO H C, et al. In vitro antimicrobial effect and in vivo preventive and therapeutic effects of partially purified lantibiotic lacticin NK34 against infection by Staphylococcus species isolated from bovine mastitis[J]. Dairy Science, 2010, 93(8): 3610-3615. |
| [15] | FOUDA M M G, EL-AASSAR M R, AL-DEYAB S S. Antimicrobial activity of carboxymethyl chitosan/polyethylene oxide nanofibers embedded silver nanoparticles[J]. Carbohydrate Polymers, 2013, 92(2): 1012-1017. |
| [16] | SCHERRER P. Estimation of size and internal structure of colloidal particles by means of R？ntgen Rays[J]. Nachr. Gottingen, 1918, 2: 98-100. |
| [17] | ZHANG M, ZHANG Y, HELLEUR R. Selective adsorption of Ag+ by ion-imprinted O-carboxymethyl chitosan beads grafted with thiourea-glutaraldehyde[J]. Chemical Engineering Journal, 2015, 264: 56-65. |
| [18] | 申宏杰, 董朝红, 吕洲. 羧甲基壳聚糖席夫碱的制备及抗菌性能研究[J]. 纤维素科学与技术, 2014, 22(4): 28-33. SHEN H J, DONG Z H, LV Z. Study on preparation and antibacterial properties of carboxymethyl chitosan[J]. Journal of Cellulose Science and Technology, 2014, 22(4): 28-33 (in Chinese). |
| [19] | MARSICH E, TRAVAN A, DONATI I, et al. Biological responses of silver-coated thermosets: An in vitro and in vivo study[J]. Acta Biomaterialia, 2013, 9(2): 5088-5099. |
| [20] | VIMALA K, MURALI M Y. Fabrication of porous chitosan films impregnated with silver nanoparticles: A facile approach for superior antibacterial application[J]. Colloids and Surfaces B: Biointerfaces, 2010, 76(1): 248-258. |
| [21] | 赵惠明, 吴建一. 甲壳素脱乙酰化研究[J]. 纺织学报, 2007, 28(9): 19-22. ZHAO H M, WU J Y. Study on the acetylation of chitin[J]. Journal of Textile Research, 2007, 28(9): 19-22 (in Chinese). |
| [22] | 韩永萍, 林强. 壳聚糖降解制备低聚壳聚糖和壳寡糖的研究进展[J]. 食品科技, 2006, 31(7): 35-38. HAN Y P, LIN Q. Research progress in the preparation of chitosan and chitosan oligosaccharide by chitosan[J]. Food Science and Technology, 2006, 31(7): 35-38 (in Chinese). |
| [23] | MOCANU A, FURTOS G, RAPUNTEAN S, et al. Synthesis: Characterization and antimicrobial effects of composites based on multi-substituted hydroxyapatite and silver nanoparticles[J]. Applied Surface Science, 2014, 298: 225-235. |
| [24] | DAMM C, MUNSTEDT H, ROSCH A. The antimicrobial efficacy of polyamide 6/silver-nano-and microcomposites[J]. Materials Chemistry and Physics, 2008, 108(1): 61-66. |
| [25] | ABDEL M A M, HRDINA R, BURGERT L, et al. Antibacterial activity and cell viability of hyaluronan fiber with silver nanoparticles[J]. Carbohydrate Polymers, 2013, 92(2): 1177-1187. |
