|
|
- 2018
全GFRP筋混凝土电缆排管的抗剪承载力
|
Abstract:
对全玻璃纤维增强聚合物复合材料（GFRP）筋混凝土电缆排管的抗剪性能进行了研究。在比较分析各国规范基础上，提出了GFRP筋混凝土电缆排管的抗剪设计计算方法。通过小尺寸和足尺GFRP筋混凝土电缆排管试件抗剪试验，得到了裂缝开展模式、截面应变分布规律及荷载挠度曲线，揭示了其破坏机制。试验结果表明，抗剪承载力均随面积配箍率和纵筋配筋率增加而增加。配箍率过小时，箍筋作用可忽略。纵筋配筋率较小时，构件仍具有较高的抗剪承载力。所提出的建议公式能满足电缆排管设计中安全性和经济性的要求。 The shear performance of the concrete cable ducts reinforced with glass fiber reinforced polymer (GFRP) bars was investigated. An appropriate calculation and design method was proposed based on the different countries' design codes. The crack growth mode, the distributions of the strain on the cross sections and the load-deflection curves were obtained by the shearing test on several small and full size specimens. The failure mechanism was revealed. The experimental results show that the shear bearing capacity increases with the increase of area-stirrup ratio and the longitudinal reinforcement ratio. The effect of stirrup on the shear bearing capacity can be neglected if the stirrup ratio is too small. The specimens still have relatively high shear bearing capacity under a small reinforcement ratio of longitudinal reinforcement. The proposed formula can preferably fulfill the requirements of security and economy for designing or fabricating the concrete cable ducts. 国家电网科技项目（WJ-03）
| [1] | 姜晓敏, 张峥, 季彤天. 预制装配技术在电缆排管工程中的应用[J]. 华东电力, 2008, 36(7):104-106. JIANG X M, ZHANG Z, JI T T. Application of pre-manufacturing and assembling technologies to cable piping projects[J]. East China Electric Power, 2008, 36(7):104-106(in Chinese). |
| [2] | 梁永春, 王忠杰, 刘建业, 等. 排管敷设电缆群温度场和载流量数值计算[J]. 高压电技术, 2007, 36(3):763-768. LIANG Y C, WANG Z J, LIU J Y, et al. Numerical calculation of temperature field and ampacity of cables in ducts[J]. High Voltage Engineering, 2007, 36(3):763-768(in Chinese). |
| [3] | 俞瑾华, 周韫捷. 电力电缆排管合理敷设长度的遗传算法[J]. 华东电力, 2012, 40(5):861-863. YU J H, ZHOU Y J. Genetic algorithm for reasonable laying length of power cable piping[J]. East China Electric Power, 2012, 40(5):861-863(in Chinese). |
| [4] | 丁一波, 穆松, 王玖凯. 基于灰色关联度的电缆排管工程施工质量评价[J]. 华东电力, 2010, 38(4):542-545. DING Y B, MU S, WANG J K. Evaluation on construction quality of cable conduit project based on grey correlation[J]. East China Electric Power, 2010, 38(4):542-545(in Chinese). |
| [5] | 陈斌, 房祥玉, 郎需军, 等. 电力电缆的排管敷设方式[J]. 电力建设, 2011, 32(3):121-123. CHEN B, FANG X Y, LANG X J, et al. Electric power laid in pipes[J]. Electric Power Construction, 2011, 32(3):121-123(in Chinese). |
| [6] | HEGGER J, KURTH M. Experimentla and theoretical study on shear capacity of concrete beams with FRP reinforcement[J]. ACI Special Publication, 2011, 10:1-8. |
| [7] | 师晓权, 张志强, 李志业, 等. GFRP筋混凝土梁抗剪承载力影响因素[J]. 西南交通大学学报, 2010, 45(6):898-903, 913. SHI X Q, ZHANG Z Q, LI Z Y, et al. Influencing factors of shear capacity of concrete beam reinforce with GFRP[J]. Journal of Southwest Jiaotong University, 2010, 45(6):898-903, 913(in Chinese). |
| [8] | 贺红卫. FRP箍筋混凝土梁受剪承载力试验研究[D]. 郑州:郑州大学, 2013. HE H W. Experimental study on the shear capacity of concrete beams with FRP stirrups[D]. Zhengzhou:Zhengzhou University, 2013(in Chinese). |
| [9] | 刘宗全, 岳清瑞, 李荣, 等. 全FRP筋混凝土梁斜截面承载力研究进展[J]. 玻璃钢/复合材料, 2017(1):109-115. LIU Z Q, YUE Q R, LI R, et al. Research progress on shear strength of concrete beams reinforced with FRP rebars and stiffups[J]. Fiber Reinforced Plastics/Composites, 2017(1):109-115(in Chinese). |
| [10] | 中华人民共和国国家质量监督检验检疫总局. 纤维增强复合材料建设工程应用技术规范:GB50608-2010[S]. 北京:中国计划出版社, 2010. General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Technical code for infrastructure application of FRP composites:GB50608-2010[S]. Beijing:China Planning Press, 2010(in Chinese). |
| [11] | American Concrete Institute. Guide for the design and construction of structural concrete reinforced with FRP bars:ACI 440.1R-06[S]. Farmington Hills:American Concrete Institute, 2015. |
| [12] | 姜庆远. FRP钢筋混凝土梁抗剪性能研究[D]. 哈尔滨:哈尔滨工业大学, 2008. JIANG Q Y. Research on shear behavior of reinforced concrete beam[D]. Harbin:Harbin Institute of Technology, 2008(in Chinese). |
| [13] | 刘承斌, 应健, 陈勇, 等. 全GFRP筋混凝土电缆排管的抗弯试验研究[J]. 复合材料学报, 2018, 35(1):2385-2395. LIU C B, YING J, CHEN Y, et al. Experimental study on flexural performance of concrete cable duct reinforced with GFRP bars[J]. Acta Materiae Compositeae Sinica, 2018, 35(1):2385-2395(in Chinese). |
| [14] | BENTZ E C, MASSAM L P, COLLINS M, et al. Shear strength of large concrete members with FRP reinforcement[J]. Journal of Composites for Construction, 2010, 6(14):637-646. |
| [15] | 梁志强. 混杂配筋混凝土梁抗剪性能研究[D]. 上海:同济大学, 2007. LIANG Z Q. Shear performance on the hybrid rein forced concrete beam[J]. Shanghai:Tongji University, 2007(in Chinese). |
| [16] | Canadian Standards Association. Canadian highway bridge design code. Standards council of canada:CAN/CSA-S6-06[S]. Toronto:Canadian Standards Association, 2010. |
| [17] | Japan Society of Civil Engineers. Recommendation for design and construction of concrete structures using continuous fiber reinforcing materials:JSCE1997[S]. Tokyo:Japan Society of Civil Engineers, 1997. |
| [18] | 中华人民共和国国家治理监督检验检疫总局. 混凝土结构设计规范:GB50010-2010[S]. 北京:中国建筑工业出版社, 2010. General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Code for design of concrete structures:GB50010-2010[S]. Beijing:China Architecture & Building Press, 2010(in Chinese). |
