|
|
- 2018
结构用橡胶集料混凝土受压全曲线试验及其本构模型
|
Abstract:
针对结构用橡胶集料混凝土（CRC）应保证与普通混凝土等强，而此类CRC单轴受压全曲线试验研究有限，尚无较成熟单轴受压本构模型的情况，分别进行了3组粒径为1~2 mm、掺量为0~100 kgm-3的CRC立方体试块单轴受压试验及棱柱体试块受压应力-应变全曲线试验。结果表明：通过综合采用NaOH碱溶液处理橡胶颗粒及配合比优化设计的方法，可以精确控制CRC与普通混凝土等强，且峰值应变及极限应变明显增加，试块破坏过程温和缓慢，破坏时完整性较好。同时，现有的普通CRC单轴受压本构模型不适用于此类结构用CRC，而普通混凝土单轴受压Carreira-Chu本构模型虽与试验曲线吻合尚可，但其对CRC的适用条件有待考证。最后，通过曲线拟合试验数据，得到以过镇海模型为基础的结构用CRC本构模型参数的建议取值，以用于此类结构构件的分析与设计。 Crumb rubber concrete(CRC) used in structures should be designed with equal strength as ordinary concrete, but the study on uniaxial compression test and constitutive model of this kind of concrete are limited. This paper conducted three groups of compression test with CRC cubes and prisms. The size was 1-2 mm and the rubber content ranged from 0 to 100 kgm-3. The results show that by pretreating the rubber particles with NaOH aqueous alkali and optimizing the mix proportion of concrete, CRC can accurately reach the same strength as ordinary concrete, while the peak strain and the ultimate strain increase obviously. The failure process of CRC specimens are mild and slow, and the specimens keep their integrity well at the failure moment. At the same time, the existing ordinary CRC constitutive models under uniaxial compression are not suitable for CRC in this study. Although Carreira-Chu constitutive model of ordinary concrete is consistent with the experimental curves, the scope of application for CRC need to be verified. Finally, through the curve fitting, the proposed values of the constitutive parameters of CRC based on the GZH model were obtained and applied in the analysis and design of CRC structural members. 国家自然科学基金（51378340；51678406）；天津市应用基础及前沿技术研究重点项目（14 JCZDJC40100-2014）
| [1] | 李强. 预应力及非预应力CRC短梁正截面抗裂性能研究[D]. 天津:天津大学, 2007. LI Qiang. Study on anti-cracking performance of prestressed and non prestressed CRC short beam[D]. Tianjin:Tianjin University, 2007(in Chinese). |
| [2] | 吕向堂. 橡胶集料混凝土与钢组合梁疲劳性能研究[D]. 天津:天津大学, 2012. LV Xiangtang. Study on fatigue properties of crumb rubber concrete-steel composite beams[D]. Tianjin:Tianjin University, 2012(in Chinese). |
| [3] | ALTAYEB M M, ABU BAKAR B H, ISMAIL H, et al. Effect of partial replacement of sand by fine crumb rubber on impact load behavior of concrete beam:Experiment and nonlinear dynamic analysis[J]. Materials & Structures, 2012, 46(8):1299-1307. |
| [4] | TAYEH A I. Effect of replacement of sand by waste fine crumb rubber on concrete beam subject to impact load:Experiment and simulation[J]. Civil & Environmental Research, 2013, 3(13):165-173. |
| [5] | CHEN B, LIU N. Experimental research on properties of fresh and hardened rubberized concrete[J]. Journal of Materials in Civil Engineering, 2014, 26(8):04014040. |
| [6] | KALOUSH K E, WAY G B, ZHU H. Properties of crumb rubber concrete[J]. Transportation Research Record Journal of the Transportation Research Board, 2005(1914):8-14. |
| [7] | SHAH S F A, NASEER A, SHAH A A, et al. Evaluation of thermal and structural behavior of concrete containing rubber aggregate[J]. Arabian Journal for Science and Engineering, 2014, 39(10):6919-6926. |
| [8] | 王庆余. 橡胶集料钢筋混凝土叠合梁受弯性能有限元分析[D]. 天津:天津大学, 2007. WANG Qingyu. Finite element analysis on the flexural behavior of reinforced crumb rubber concrete composite beams[D]. Tianjin:Tianjin University, 2007(in Chinese). |
| [9] | 纪丽静. 橡胶混凝土受弯构件力学性能试验研究[D]. 厦门:华侨大学, 2010. JI Lijing. Experimental study on mechanical properties of crumb rubber concrete flexural members[D]. Xiamen:Huaqiao University, 2010(in Chinese). |
| [10] | 王婧一, 王立燕, 张亚梅. 弹性橡胶集料混凝土压、弯变形性能试验研究[J]. 混凝土与水泥制品, 2008(2):6-10. WANG Jingyi, WANG Liyan, ZHANG Yamei. Experimental study on compressive and flexural deformation properties of elastic crumb rubber concrete[J]. Concrete and Cement Products, 2008(2):6-10(in Chinese). |
| [11] | YOUSSF O, ELGAWADY M A, MILLS J E, et al. An experimental investigation of crumb rubber concrete confined by fibre reinforced polymer tubes[J]. Construction & Building Materials, 2013, 53(4):145-167. |
| [12] | XING Y, HAN Q, XU J, et al. Experimental and numerical study on static behavior of elastic concrete-steel composite beams[J]. Journal of Constructional Steel Research, 2016, 123:79-92. |
| [13] | 中国人民共和国住房和城乡建设部. 普通混凝土力学性能试验方法标准:GB/T 50081-2002[S]. 北京:中国建筑工业出版社, 2003. Ministry of Housing and Urban Rural Development of the People's Republic of China. Standard test method for mechanical properties of ordinary concrete:GB/T 50081-2002[S]. Beijing:China Architecture & Building Press, 2003(in Chinese). |
| [14] | 许静. 橡胶集料混凝土阻尼测试及框架结构设计分析[D]. 天津:天津大学, 2007. XU Jing. Damping test of crumb rubber concrete and the analysis of frame structure design[D]. Tianjin:Tianjin University, 2007(in Chinese). |
| [15] | TAYEH A. Investigations of the effect of high percentage of waste fine crumb rubber on rubberized concrete beam subject to impact load[J]. Innovative Systems Design & Engineering, 2014, 5(1):48-55. |
| [16] | YOUSSF O, ELGAWADY M A, MILLS J. Behaviour of FRP-confined crumb rubber concrete columns under seismic loading[C]//Proceedings of the 5th International Conference on Construction Materials:Performance, Innovations and Structural Implications. Whistler, 2015. |
| [17] | 李悦, 吴玉生, 杨玉红, 等. 钢筋橡胶集料混凝土结构性能研究[J]. 北京工业大学学报, 2008, 34(12):1280-1285. LI Yue, WU Yusheng, YANG Yuhong, et al. Study on structural properties of reinforced crumb rubber concrete[J]. Journal of Beijing University of Technology, 2008, 34(12):1280-1285(in Chinese). |
| [18] | HAN Qinghong, WANG Yihong, XU Jie, et al. Static behavior of stud shear connectors in elastic concrete-steel composite beams[J]. Journal of Constructional Steel Research, 2015, 113:115-126. |
| [19] | WANG G, ZHANG B, SHUI Z, et al. Experimental study on the performance and microstructure of rubberized lightweight aggregate concrete[J]. Progress in Rubber Plastics Recycling Technology, 2012, 28(4):147-156. |
| [20] | 熊杰, 郑磊, 袁勇. 废橡胶集料混凝土抗压强度试验研究[J]. 混凝土, 2004(12):40-42. XIONG Jie, ZHENG Lei, YUAN Yong. Experimental study on compressive strength of crumb rubber concrete[J]. Concrete, 2004(12):40-42(in Chinese). |
| [21] | 袁琳. 橡胶集料钢筋混凝土梁受弯性能初探[J]. 混凝土, 2005(6):70-76. YUAN Lin. Study on the flexural behavior of reinforced crumb rubber concrete beams[J]. Concrete, 2005(6):70-76(in Chinese). |
| [22] | CARREIRA D J, CHU K H. Stress-strain relationship for plain concrete in compression[J]. Journal of the American Concrete Institute, 1985, 82(6):797-804. |
| [23] | 过镇海, 张秀琴, 张达成, 等. 混凝土应力-应变全曲线的试验研究[J]. 建筑结构学报, 1982, 3(1):3-14. GUO Zhenhai, ZHANG Xiuqin, ZHANG D C, et al. Experimental study on stress-strain curves of concrete[J]. Journal of Building Structures, 1982, 3(1):3-14(in Chinese). |
| [24] | 中国人民共和国住房和城乡建设部. 混凝土结构设计规范:GB50010-2010[S]. 北京:中国建筑工业出版社, 2011. Ministry of Housing and Urban Rural Development of the People's Republic of China. Code for design of concrete structures:GB50010-2010[S]. Beijing:China Architecture & Building Press, 2011(in Chinese). |
| [25] | 刘锋, 潘东平, 李丽娟, 等. 低强橡胶集料混凝土单轴受压本构关系的试验研究[J]. 建筑材料学报, 2007, 10(4):407-411. LIU Feng, PAN Dongping, LI Lijuan, et al. Experimental study on constitutive relation of low strength crumb rubber concrete under uniaxial compression[J]. Journal of Building Materials, 2007, 10(4):407-411(in Chinese). |
| [26] | 杨敏. 废旧橡胶集料混凝土基本力学性能研究[D]. 沈阳:沈阳大学, 2012. YANG Min. Study on basic mechanical properties of crumb rubber concrete[D]. Shenyang:Shenyang University, 2012(in Chinese). |
| [27] | ASWATH P B, SIRINGI G M, ABOLMAALI A. Properties of concrete with crumb rubber replacing fine aggregates (sand)[J]. Journal of Pharmaceutical Sciences, 2013, 2(1):218-232. |
| [28] | 袁群, 冯凌云, 曹宏亮, 等. 橡胶集料混凝土的应力-应变曲线试验[J]. 建筑科学与工程学报, 2013, 30(3):96-100. YUAN Qun, FENG Lingyun, CAO Hongliang, et al. Stress strain curve test of crumb rubber concrete[J]. Journal of Architecture and Civil Engineering, 2013, 30(3):96-100(in Chinese). |
| [29] | TOP？U B I. The properties of rubberized concrete[J]. Cement and Concrete Research, 1995, 25(25):304-310. |
| [30] | KHALOO A R, DEHESTANI M. RAHMATABADI P. Mechanical properties of concrete containing a high volume of tire-rubber particles[J]. Waste Management, 2008, 28(12):2472-2482. |
| [31] | 董建伟, 袁琳, 朱涵. 橡胶集料混凝土的试验研究及工程应用[J]. 混凝土, 2006(7):69-71. DONG Jianwei, YUAN Lin, ZHU Han. Experimental study and engineering application of crumb rubber concrete[J]. Concrete, 2006(7):69-71(in Chinese). |
| [32] | 阮盛华. 低掺量橡胶集料混凝土单轴受压本构关系改进研究[D]. 广东:广东工业大学, 2013. RUAN Shenghua. Improvement of constitutive relation of low volume crumb rubber concrete under uniaxial compression[D]. Guangdong:Guangdong University of Technology, 2013(in Chinese). |
| [33] | 冯文贤, 魏宜达, 李丽娟, 等. 高强橡胶集料混凝土单轴受压本构关系的试验研究[J]. 新型建筑材料, 2010, 37(2):12-15. FENG Wenxian, WEI Yida, LI Lijuan, et al. Experimental study on constitutive relation of high strength crumb rubber concrete under uniaxial compression[J]. New Building Material, 2010, 37(2):12-15(in Chinese). |
| [34] | 朱涵, 刘春生, 张永明, 等. 橡胶掺量对混凝土压弯性能的影响[J]. 天津大学学报(自然科学与工程技术版), 2007, 40(7):761-765. ZHU Han, LIU Chunsheng, ZHANG Yongming, et al. Effect of rubber content on compressive and flexural behavior of concrete[J]. Journal of Tianjin University (Natural Science and Engineering Technology Edition), 2007, 40(7):761-765(in Chinese). |
| [35] | 王旻, 朱涵, 刘爱军. CL30橡胶轻集料混凝土应力应变全曲线试验研究[J]. 粉煤灰综合利用, 2008(6):17-19. WANG Yu, ZHU Han, LIU Aijun. Experimental study on stress-strain curves of CL30 crumb rubber concrete[J]. Fly Ash Comprehensive Utilization, 2008(6):17-19(in Chinese). |
| [36] | YAN J B, LI Z X, XIE J. Numerical and parametric studies on steel-elastic concrete composite structures[J]. Journal of Constructional Steel Research, 2017, 133:84-96. |
| [37] | NOAMAN A T, ABU BAKAR B H, AKIL H M. Influence of crumb rubber on impact energy of steel fiber concrete beams[J]. Applied Mechanics & Materials, 2015, 802:196-201. |
