|
|
- 2017
电动汽车主动悬架系统阻尼可调减振器设计及固有频率试验
|
Abstract:
为了增加电动汽车主动悬架系统阻尼可调减振器的工作模式及其调节范围，以某液压减振器为基础，设计了一种阻尼多模式切换可调的减振器.分析了阻尼多模式切换可调减振器的工作原理及其阻尼特性.基于阻尼多模式切换可调减振器的“软压缩软回弹”、“硬压缩软回弹”、“软压缩硬回弹”和“硬压缩硬回弹”工作模式，设计了阻尼多模式切换可调减振器减振支柱总成和电磁阀总成.同时设计了基于INSTRON8800单通道数字控制液压伺服激振台的阻尼多模式切换可调减振器试验台架系统，进行了不同阻尼模式下的固有频率试验和车身振动加速度响应的频谱分析.结果表明：后悬架簧上质量的固有频率均高于前悬架，比值关系接近于1.2:1，后悬架的簧下质量固有频率小于前悬架，比值关系约为1:1.1~1:1，反映了阻尼多模式切换可调减振器在压缩行程和回弹行程阻尼特性的可行性，对主动悬架系统及其控制策略的设计具有重要的理论研究价值和工程应用前景.
In order to increase the damping adjustable working modes and expand the adjustment range of the active suspension system of electrically powered vehicles, a multi-mode switching adjustable shock absorber was designed based on a hydraulic damper shock absorber. Its working principle and damping characteristics were analyzed. A strut-suspension assembly and an electromagnetic valve assembly of the shock absorber were designed based on its different working modes:'soft compression & soft rebound', 'hard compression & soft rebound', 'soft compression & hard rebound' and 'hard compression & hard rebound'. A bench test system was designed based on the INSTRON8800 single channel digital control hydraulic servo vibration table. A natural frequency test and a frequency spectrum analysis of vibration acceleration response of the body under different damping modes were carried out. The results showed that the natural frequency of the rear suspension spring was higher than that of the front suspension, with a ratio of about 1.2:1, and that the natural frequency of the rear suspension was lower than that of the front suspension, the ratio being about 1:1.1~1:1. It is expected that the results of this study is of important theoretical value and has a good engineering application prospect for active suspension system and its control strategy
| [1] | LI ZHONGJIE, LEI ZUO, LUHRS GEORGE, et al. Electromagnetic Energy-Harvesting Shock Absorbers:Design, Modeling, and Road Tests[J]. IEEE Transactions on Vehicular Technology, 2013, 62(3): 1065-1074. DOI:10.1109/TVT.2012.2229308 |
| [2] | 汪若尘, 张孝良, 陈龙, 等. 车身高度与可调阻尼集成控制系统[J]. 农业工程学报, 2012, 28(11): 75-79. DOI:10.3969/j.issn.1002-6819.2012.11.013 |
| [3] | KINAGI G V, PITCHUKA S P, SONWANE D. Hydro Pneumatic Suspension Design for Light Military Tracked Vehicle[J]. Commercial Vehicle Engineering Congress, 2012, 2(11): 111-120. |
| [4] | LIN Jin-shan. Identification of Road Surface Power Spectrum Density Based on a New Cubic Spline Weight Neural Network[J]. Energy Procedia, 2012, 7(17): 534-549. |
| [5] | KURFESS, THOMAS R, MESSMAN, et al. A Methodology to Integrate a Nonlinear Shock Absorber Dynamics Into a Vehicle Model for System Identification[J]. SAE International Journal of Materials and Manufacturing, 2011, 4(1): 527-534. DOI:10.4271/2011-01-0435 |
| [6] | NONG ZHANG, WADE A SMITH, JEKU JEYAKUMARAN. Hydraulically Interconnected Vehicle Suspension:Background and Modeling[J]. Vehicle System Dynamics, 2010(1): 17-40. |
| [7] | TUNG S L, JUANG Y T, LEE W H, et al. Optimization of the Exponential Stabilization Problem in Active Suspension System Using PSO[J]. Expert Systems with Applications, 2011, 38: 14044-14051. |
| [8] | KIM H, LEE H. Fault-Tolerant Control Algorithm for a Four-Corner Closed-Loop Air Suspension System[J]. IEEE Transactions on Industrial Electronics, 2011, 58(10): 4866-4879. DOI:10.1109/TIE.2011.2123852 |
| [9] | 江洪, 刁怀伟, 曹威, 等. 电动汽车减速器振动特性分析及噪声辐射预测[J]. 重庆理工大学学报(自然科学版), 2016, 30(1): 7-14. |
| [10] | GYSEN B L J, JANSSEN J L G, PAULIDES J J H, et al. Efficiency of a Regenerative Direct-Drive Electromagnetic Active Suspension[J]. IEEE Transactions on Vehicular Technology, 2011, 60(4): 1384-1392. DOI:10.1109/TVT.2011.2131160 |
| [11] | 江浩斌, 胡隽秀, 陈龙, 等. 两级阻尼可调式液压减振器的性能仿真与试验[J]. 机械工程学报, 2010, 46(22): 117-122. |
| [12] | ZEHSAZ M, SADEGHI M H, ETTEFAGH M M, et al. Tractor Cabin's Passive Suspension Parameters Optimization Via Experimental and Numerical Methods[J]. Journal of Terramechanics, 2011, 48: 439-450. DOI:10.1016/j.jterra.2011.09.005 |
| [13] | KINAGI G V, PITCHUKA S P, SONWANE D. Hydro Pneumatic Suspension Design for Light Military Tracked Vehicle[J]. Commercial Vehicle Engineering Congress, 2012, 2(11): 111-120. |
| [14] | 唐传茵, 张天侠. 汽车振动舒适性评价研究[J]. 振动与冲击, 2008, 27(9): 158-161, 166. |
| [15] | 赵强, 何法, 王鑫, 等. 基于遗传算法优化的车辆主动悬架模糊PID控制[J]. 重庆理工大学学报(自然科学版), 2016, 30(2): 6-11. |
