This paper investigated the analyses of removal of Methylene Blue (MB) and Brilliant Green (BG) dyes from aqueous solutions by adsorption on activated carbon prepared by chemical activation of coconut shell, eucalyptus tree, corn cob and flamboyant pod. It was found that the carbon pores increased after carbonization and activation processes. The maximum percentage MB removal was obtained as 95.0% for coconut shell, 93.2% for eucalyptus tree, 99.9% for corn cob, and 99.7% for flamboyant pod. Also, the maximum percentage BG removal was obtained as 97.0% for coconut shell, 98.2% for eucalyptus tree, 99.6% for corn cob, and 99.6% for flamboyant pod. The adsorption isotherms of the adsorption process were studied, and Freundlich model showed the best fit with the equilibrium data. To optimize the operating conditions, the effects of contact time, adsorbent dosage, and pH were investigated by two levels of factorial experimental design method and adsorbent dosage was found as the most significant factor.
References
[1]
ElQada, E.N., Allen, S.J. and Walker, G.M. (2008) Adsorption of Basic Dyes from Aqueous Solution onto Activated Carbons. Chemical Engineering Journal, 135, 174-184. https://doi.org/10.1016/j.cej.2007.02.023
[2]
Cooper, P. (1993) Removing Colour from Dyehouse Wastewaters—A Critical Review of technology Available. Journal of the Society of Dyers and Colourists, 109, 97-100.
[3]
Jadhav, S.B., Phugare, S.S., Patil, P.S. and Jadhav, J.P. (2011) Biochemical Degradation Pathway of Textile Dye Remazol Red and Subsequent Toxicological Evaluation by Cytotoxicity, Genotoxicity and Oxidative Stress Studies. International Biodeterioration and Biodegradation, 65, 733-743. https://doi.org/10.1016/j.ibiod.2011.04.003
[4]
Gupta, V.K., Gupta, B., Rastogi, A., Agarwal, S. and Nayak, A. (2011) A Comparative Investigation on Adsorption Performances of Mesoporous Activated Carbon Prepared from Waste Rubber Tire and Activated Carbon for a Hazardous Azo Dye—Acid Blue 113. Journal of Hazardous Materials, 186, 891-901. https://doi.org/10.1016/j.jhazmat.2010.11.091
[5]
Bonnamy, S. (1999) Carbonization of Various Precursors. Effect of Heating Rate. Part II. Transmission Electron Microscopy and Physicochemical Studies. Carbon, 37, 1707-1724. https://doi.org/10.1016/S0008-6223(99)00044-5
[6]
Bourrat, X. (1997) Structure in Carbons and Carbon Artefacts. In: Marsh, H. and Rodriguez-Reinoso, F., Eds., Sciences of Carbon Materials, Universidad de Alicante, Secretariado de Publications, Spain, 1-97.
[7]
Marsh, H., Heintz, E.A. and Rodriguez-Reinoso, F., Eds. (1997) Introduction to Carbon Technologies. Universidad de Alicante, Secretariado de Publications, Spain, 669.
[8]
Marsh, H. and Rodriguez-Reinoso, F., Eds. (2000) Science of Carbon Materials. Universidad de Alicante, Secretariado de Publications, Spain, 673.
[9]
Marsh, H. (2001) Carbon Mesophase. In: Buschew, K.H, Cahn, J., Robert, W., Flemings Merten, C., IIscher, B., Kramer Edward, J., Subhash, M. and Patrick, V., Eds., Encyclopedia of Materials: Science and Technology, Elsevier Science Ltd., Amsterdam, 926-932. https://doi.org/10.1016/B0-08-043152-6/00177-7
[10]
Mattson, J.S. and Mark, H.B. (1971) Activated Carbon. Marcel Dekker Inc., New York, 237.
[11]
McGuire, M.J. and Suffet, I.H., Eds. (1980) Activated Carbon Adsorption of Organics from the Aqueous Phase, Vol. 1. Ann Arbor Science Publishers Inc., Michigan, 508.
[12]
McGuire, M.J. and Suffet, I.H., Eds. (1980) Activated Carbon Adsorption of Organics from the Aqueous Phase, Vol. 2. Ann Arbor Science Publishers Inc., Michigan, 589.
[13]
McGuire, M.J. and Suffet, I.H., Eds. (1983) Treatment of Water by Granular Activated Carbon, Advances in Chemistry Series, 202. American Chemical Society, Washington, 599. https://doi.org/10.1021/ba-1983-0202