|
|
- 2018
碱侵蚀对玄武岩纤维/沥青流变性能的影响
|
Abstract:
为增强玄武岩纤维（BF）/沥青流变性能，采用1.0 mol/L及2.5 mol/L NaOH溶液对BF进行侵蚀，通过ESEM试验和FTIR试验对其表面细观形貌进行了细观观测及分析。结果表明：原样BF表面光滑，NaOH侵蚀后的BF呈现明显的NaOH产物包裹BF现象，且随着NaOH的浓度及侵蚀时间的增加，BF的—OH含量增加；通过ESEM试验、动态剪切流变仪（DSR）试验及低温弯曲流变仪（BBR）试验，研究了BF/沥青的拉拔断口形貌及流变性能。结果表明：随着BF的侵蚀程度越严重，沥青与BF粘结性能和BF/沥青流变性能越好，且得到了NaOH对BF侵蚀的最佳侵蚀时间和浓度分别为45 min和2.5 mol/L。 In order to enhance the rheological properties of the basalt fiber(BF)/asphalt, BF was eroded by 1.0 mol/L and 2.5 mol/L NaOH solution. The micro topography of the BF surface was observed and analyzed by ESEM and FTIR test. The results show that the original BF is smooth, The BF erod by the NaOH shows a clear phenomenon of the NaOH products coating the BF, and with the increase of NaOH solution concentration and erosion time, the content of hydroxyl (-OH) of the BF is higher; The BF/asphalt of drawing fracture morphology and rheological properties were studied by ESEM、dynamic shear rheometer (DSR) and bending beam rheometer (BBR) test. The results show that the higher the degree of erosion of the BF by NaOH solution, the better the bond behavior of the asphalt with the BF and the rheological properties of the BF/asphalt, and the best erosion time and concentration of NaOH solution for BF erosion are 45 min and 2.5 mol/L, respectively. 国家自然科学基金（51678078）
| [1] | 张洪刚. 水-温冻融条件下沥青路面病害特征及发展机理[D]. 长沙:长沙理工大学, 2010:5-10. ZHANG Honggang. Damage characteristics and development mechanism of asphalt pavement under freeze-thaw with water and temperature[D]. Changsha:Changsha University of Science & Technology, 2010:5-10(in Chinese). |
| [2] | 陈昌宇. 玄武岩纤维沥青混合料路用性能与应用研究[D]. 长沙:长沙理工大学, 2012:2-7. CHENG Chanyu. Basalt fiber bituminous mixture properties and the application research[D]. Changsha:Changsha University of Science & Technology, 2012:2-7(in Chinese). |
| [3] | 刘朝晖, 曹强, 周昕, 等. 玄武岩纤维对SMA-13沥青混合料性能影响研究[J]. 公路工程, 2015, 40(3):1-4. LIU Zhaohui, CAO Qiang, ZHOU Xin, et al. Study on the impact of SMA-13 asphalt mixture's performance with basalt fiber[J]. Highway Engineerinng, 2015, 40(3):1-4(in Chinese). |
| [4] | 刘福军. 玄武岩纤维沥青混合料路用性能研究[D]. 哈尔滨:哈尔滨工业大学, 2010:3-6. LIU Fujun. Study on performance of asphalt mixture with basalt fiber[D]. Harbin:Harbin Institute of Technology, 2010:3-6(in Chinese). |
| [5] | 赵丽华, 徐刚. 矿物纤维对沥青混合料路用性能影响及机理分析[J]. 公路工程, 2013, 38(1):203-207. ZHAO Lihua, XU Gang. Influence of mineral fiber on road performance of asphalt mixture and mechanism analysis[J]. Highway Engineering, 2013, 38(1):203-207(in Chinese). |
| [6] | 范文孝. 玄武岩纤维增强路面材料性能试验研究[D]. 大连:大连理工大学, 2010. FAN Wenxiao. Experimental investigation on performance of basalt fiber-reinforced pavement materials[D]. Dalian:Dalian University of Technology, 2010(in Chinese). |
| [7] | FAN Wenxiao, KANG Haigui, ZHENG Yuanxun. Experimental study of pavement performance of basalt fiber-modified asphalt mixture[J]. Journal of Southeast University(English Edition), 2010, 26(4):614-617. |
| [8] | 徐刚, 赵丽华, 赵晶. 玄武岩矿物纤维改善沥青混合料性能研究[J]. 公路, 2011(6):167-170. XU Gang, ZHAO Lihua, ZHAO Jing. Research on performance of basalt fiber-enhanced asphalt mixture[J]. Highway, 2011(6):167-170(in Chinese). |
| [9] | 徐刚. 纤维沥青混合料增强机理及性能研究[D]. 大连:大连理工大学, 2012. XU Gang. Study of performance and reinforced mechanism of the fiber asphalt mixtures[D]. Dalian:Dalian University of Technology, 2012(in Chinese). |
| [10] | 于斌. 纤维沥青胶浆流变特性及纤维沥青混合料路用性能研究[D]. 西安:长安大学, 2009. YU Bin. Rheological characteristic of fiber reinforced asphalt mortar and the pavement performance of fiber reinforced asphalt mixtures[D]. Xi'an:Chang'an University, 2009(in Chinese). |
| [11] | 王辉. 不同纤维对SMA路用性能影响研究[D]. 长沙:长沙理工大学, 2007. WANG Hui. Study on different fibres influences on pavement performances of SMA[D]. Changsha:Changsha University of Science & Technology, 2007(in Chinese). |
| [12] | 刘克非. 不同纤维对SMA路用性能的影响[J]. 长安大学学报(自然科学版), 2011, 31(4):16-21. LIU Kefei. Influence of different fibers on road performance of SMA[J]. Journal of Chang'an University(Natural Science Edition), 2011, 31(4):16-21(in Chinese). |
| [13] | 杨彦海, 卞旺奎, 杨野, 等. 不同纤维掺量下SMA-13路用性能横向对比研究[J]. 公路, 2017(3):18-23. YANG Yanhai, BIAN Wangkui, YANG Ye, et al. Transverse comparison and research on the pavement performance of SMA-13 with different fiber content[J]. Highway, 2017(3):18-23(in Chinese). |
| [14] | 刘朝晖, 向宇, 柳力, 等. 偶联改性玄武岩纤维沥青胶浆流变性能研究[J]. 公路, 2016(7):235-239. LIU Zhaohui, XIANG Yu, LIU Li, et al. Research on rheological properties of the basalt fiber with coupling treatment modified asphalt mortar[J]. Highway, 2016(7):235-239(in Chinese). |
| [15] | 刘朝晖, 向宇, 柳力, 等. 偶联改性玄武岩纤维增强沥青胶浆性能及机理研究[J]. 玻璃钢/复合材料, 2016(5):5-11. LIU Zhaohui, XIANG Yu, LIU Li, et al. Study of performance and enhancement mechanism of silane coupling agent modified basalt fiber reinforced asphalt mucilage[J]. Fiber Reinforced Plastics/Composites, 2016(5):5-11(in Chinese). |
| [16] | 向宇, 刘朝晖, 柳力, 等. 偶联改性玄武岩纤维增强沥青胶浆性能及机理研究[J]. 玻璃钢/复合材料, 2016(5):5-11. XIANG Yu, LIU Zhaohui, LIU Li, et al. Study of performance and enhancement mechanism of silane coupling agent modified basalt fiber reinforced asphalt mucilage[J]. Fiber Reinforced Plastics/Composites, 2016(5):5-11(in Chinese). |
| [17] | 柳力, 刘朝晖, 向宇, 等. 硅烷偶联剂改性玄武岩纤维机理及路用性能[J]. 建筑材料学报, 2017, 20(1):150-155. LIU Li, LIU Zhaohui, XIANG Yu, et al. Mechanism and road performance of basalt fiber modified by silane coupling agent[J]. Journal of Building Materials, 2017, 20(1):150-155(in Chinese). |
| [18] | 刘朝晖, 周婷, 秦仁杰, 等. 基于抗车辙性能的长大纵坡沥青混合料设计[J]. 中国科技论文, 2013, 8(11):1105-1109. LIU Zhaohui, ZHOU Ting, QIN Renjie, et al. Asphalt mixture design on long steep asphalt pavement based on the rutting resistance performance[J]. China Sciencepaper, 2013, 8(11):1105-1109(in Chinese). |
| [19] | WANG Dong, WANG Linbing, GU Xinyu, et al. Effect of basalt fiber on the asphalt binder and mastic at low temperature[J]. Journal of Materials in Civil Engineering, 2013, 25(3):355-364. |
| [20] | SIM J, PARK C, MOON D Y. Characteristics of basalt fiber as a strengthening material for concrete structures[J]. Composites Part B:Engineering, 2005, 36(6-7):504-512. |
| [21] | 王宁. 玄武岩纤维及其改性沥青的性能研究[D]. 武汉:中国地质大学, 2013. WANG Ning. Study on property of basalt fiber and basalt fiber modified asphalt[D]. Wuhan:China University of Geosciences, 2013(in Chinese). |
