全部 标题 作者
关键词 摘要

OALib Journal期刊
ISSN: 2333-9721
费用:99美元

查看量下载量

相关文章

更多...

宋代银制品模拟样品在Na2S溶液中的电化学腐蚀及其产物

, PP. 1-6

Keywords: ,腐蚀,电化学,Ag2S

Full-Text   Cite this paper   Add to My Lib

Abstract:

研究了2008年南京长干寺出土的北宋七宝阿育王塔鎏金银基体及其腐蚀产物成分,并根据银基体成分按传统工艺自行冶炼、加工出模拟的银试样.用电化学、OM、XRD、XRF、SEM-EDS技术研究并比较了银试样在不同浓度Na2S溶液中的腐蚀电位与电流、腐蚀产物成分、形貌、晶粒度等.结果表明,Na2S浓度由20mg/L升高到5.0×104mg/L(5%Na2S)时,自腐蚀电位Ecorr负移0.70V,自腐蚀电流密度Icorr从0.274μA/cm2升高至1.056μA/cm2,腐蚀倾向和速度大幅度增加.在20mg/LNa2S溶液中-0.31V~1.8V范围内极化,银试样始终处于活化溶解状态.在5%Na2S溶液中,腐蚀活化区电流密度从1.056μA/cm2迅速升高至1.56×104μA/cm2,并以较大的腐蚀电流密度(约1.56×104μA/cm2)进入钝化区并维持钝态;分别在20mg/L和5%Na2S溶液中活化区恒电位+0.3V、-0.8V极化不同时间后,腐蚀产物主要为Ag2S.随着Na2S溶液浓度的增大,试样表面S2-腐蚀活性中心增多,Ag2S晶体成核速率增大,而腐蚀产物的晶粒度则由20μm减小到1.86~5.10nm.

References

[1]  Rice D W, Peterson P, Rigby E B. Atmospheric corrosion of copper and silver [J]. J. Electrochem. Soc., 1981, 28(2): 275
[2]  Volpe L, Peterson P J. The atmosphere sulfidation of silver in a tubular corrosion reactor [J]. Corros. Sci., 1989, 29(10): 1179
[3]  Praney J P, Kammlott G W, Graedel T E. The corrosion of silver by atmospheric sulfurous gas [J]. Corros. Sci., 1985, 25(2): 133
[4]  Reagor B T, Sinclair J D. Tarnishing of silver by sulfur vapor: Film characteristics and humidity effects [J]. J. Electrochem. Soc., 1981, 128(3): 701
[5]  徐军平, 郑捷. 两件鎏金青铜器的腐蚀分析与保护 [A]. 中国文物保护技术协会第四次学术年会论文集 [C]. 北京: 科学出版社, 2005: 38
[6]  Graedel T E, Kammlott G W, Franey J P. Carbonyl sulfide: potential agent of atmospheric sulfur corrosion [J]. Science, 1981, 212: 664
[7]  Sinclair J D. Tarnishing of silver by organic sulfur vapors: Rates and film characteristics [J]. J. Electrochem. Soc., 1982, 129(1): 33
[8]  祝鸿范, 周浩, 蔡兰坤等. 银器文物的变色原因及防变色缓蚀剂的筛选 [J]. 文物保护与考古科学, 2001, 13(1): 15
[9]  沈大娲, 梁宏刚, 孔祥山. 中国钱币博物馆部分陈列银币、铜币的腐蚀产物及成因研究 [J]. 文物保护与考古科学, 2008, 20(1): 33
[10]  Yang C J, Liang C H, Wang P. Investigation of the tarnish on the surface of a panda gold coin [J]. Rare Met., 2007, 26(1): 68
[11]  Yang C J, Liang C H, Wang P, et al. Investigation of the tarnish film on the surface of commemoration silver coin [J]. Rare Met. Mater. Eng., 2007, 36(4): 629
[12]  Kleber C, Wiesinger R, Schn?ller J, et al. Initial oxidation of silver surfaces by S2- and S4+ species [J]. Corros. Sci., 2008, 50: 1112
[13]  Bastidas D M, Cano E, González A G, et al. An XPS study of tarnishing of a gold mask from a pre-Columbian culture [J]. Corros. Sci., 2008, 50: 1785
[14]  Fukuda T, Fukushima Y. Indoor corrosion of copper and silver exposed in Japan and Asean countries [J]. J. Electrochem. Soc., 1991, 138(5): 1238
[15]  Mayerhofer K E, Piplits K, Traum R, et al. Investigations of corrosion phenomena on gold coins with SIMS [J]. Appl. Surf. Sci., 2005, 252: 133
[16]  Hallett K, Thickett D, Mcphail D S, et al. Application of SIMS to silver tarnish at the British Museum [J]. Appl. Surf. Sci., 2003, 203-204: 789
[17]  杨忙忙, 齐扬. 法门寺金银器蚀变因素分析 [A]. 中国文物保护技术协会第四次学术年会论文集 [C]. 北京: 科学出版社, 2005
[18]  Yang Q Q, Xiong W H, Yang Z, et al. Corrosion and tarnish behaviour of 925Ag75Cu and 925Ag40Cu35Zn alloys in synthetic sweat and H2S atmosphere [J]. Rare Met. Mater. Eng., 2010, 39(4): 0578
[19]  Kim H. Corrosion process of silver in environments containing 0.1 ppm H2S and 1.2 ppm NO2 [J]. Mater. Corros., 2003, 54(4): 243
[20]  Chen M, Xie Y, Chen H Y, et al. Preparation and characterization of metal sulfides in ethylenediamine under ambient conditions through a γ-irradiation route [J]. J. Colloid Inter. Sci., 2001, 237: 47
[21]  Liu J C, Raveendran P, Shervani Z, et al. Synthesis of Ag2S quantum dots in water-in-CO2 microemulsions [J]. Chem. Commun., 2004, (22): 2582
[22]  Pei L W, Zhang Z H, Yee L H, et al. Preparation of Ag2S nanocrystals of predictable shape and size [J]. Angew. Chem., 2004, 116: 5803
[23]  刘利生, 周少敏, 苑红磊等. 半导体硫化银纳米球的控制合成及室温气敏性 [J]. 科学通报, 2011, 56(27): 2344

Full-Text

Contact Us

service@oalib.com

QQ:3279437679

WhatsApp +8615387084133